Influence of brick dust, stone dust, and recycled fine ...

2020-8-12  The present paper study the effect of partial substitution of brick dust (BD), stone dust (SD), and recycled fine aggregate (RFA) as fine aggregate on the properties of natural aggregate concrete (NAC) and recycled aggregate concrete (RAC). In the present investigation, two groups of mixes were considered: Group A consists of 100% natural ...

Get Price

Replacement of stone Dust and Ceramic scrap as

2020-10-31  Compressive strength of concrete made using 05 % ceramic waste aggregate and 05 % stone dust as replacement of coarse aggregate and fine aggregate respectively, is about 20% more than that of referral concrete at 28 days. However, compressive strength at 05% recycled aggregate and 05% stone dust is marginally than that of conventional concrete.

Get Price

UTILIZATION OF WASTE BY USING STONE DUST AS FINE

Utilization of recycled fiber obtained from condensed milk-can and stone dust will benefit in term of waste reduction, recycling of waste and would provide low-cost construction material. The

Get Price

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15  1. Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete. 2. The concept of replacement of natural fine aggregate (sand) by quarry dust may help in many ways such as it is helpful to control environment pollution, erosion of river bank might stop and also the waste quarry material can be

Get Price

(PDF) Crushed stone waste as fine aggregate for concrete

In general, aggregate is a group of coarse to intermediate grained particulate materials such as gravel, sand, crushed stone [1], recycled aggregate [2], slag [3] and

Get Price

(PDF) An Experimental Investigation on Stone Dust as ...

It is observed that the compressive strength of concrete made using 10% recycled aggregate and 60% stone dust as replacement of coarse aggregate and fine aggregate respectively, is about 11% more ...

Get Price

An Experimental study on Crushed Stone Dust as Fine ...

2018-1-1  The Narmada River sand is used as NS. (ii) Crushed Stone dust is a fine material formed during the process of conversion of rock into aggregate and has particle size ranging from 4 mm to dust size (> 0.075mm). It was procured from stone crusher plant producing 20 mm downgraded aggregate, M/s Maa Pitambara Stone situated at Neelbad, Bhopal (India).

Get Price

Investigation on ceramic waste and stone dust as

2020-8-27  presents the use of stone dust—a byproduct of crushers as replacement of fine aggregate and ceramic waste as a replacement of coarse aggregate. This study was conducted to analyse the compressive and flexural strength of concrete when natural sand was replaced with stone dust at 20%, 40 %, 60%, 80 % and 100% along with

Get Price

Choice Of Quarry Rock Dust Over Natural Sand As Fine

1 Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete 2 The concept of replacement of natural fine aggregate sand by quarry dust may help in many ways such as it is helpful to control environment pollution erosion of river bank might stop and also the waste quarry material can be. Read More.

Get Price

Alternative fine aggregates in production of sustainable ...

2020-9-20  The decrease in elastic modulus seemed to be linear with the increase in recycled fine aggregates content (Poon and Kou, 2010). However, Etxeberria and Vegas (2014) observed that modulus of elasticity of fine ceramic recycled aggregate (RA) and mixed fine RA concretes were similar to those of control concrete.

Get Price

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15  1. Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete. 2. The concept of replacement of natural fine aggregate (sand) by quarry dust may help in many ways such as it is helpful to control environment pollution, erosion of river bank might stop and also the waste quarry material can be

Get Price

Choice Of Quarry Rock Dust Over Natural Sand As Fine

1 Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete 2 The concept of replacement of natural fine aggregate sand by quarry dust may help in many ways such as it is helpful to control environment pollution erosion of river bank might stop and also the waste quarry material can be. Read More.

Get Price

Investigation on ceramic waste and stone dust as

2020-8-27  presents the use of stone dust—a byproduct of crushers as replacement of fine aggregate and ceramic waste as a replacement of coarse aggregate. This study was conducted to analyse the compressive and flexural strength of concrete when natural sand was replaced with stone dust at 20%, 40 %, 60%, 80 % and 100% along with

Get Price

Study on Compressive Strength of Quarry Dust as Fine ...

2016-7-28  The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

Get Price

An Experimental study on Crushed Stone Dust as Fine ...

2018-1-1  The Narmada River sand is used as NS. (ii) Crushed Stone dust is a fine material formed during the process of conversion of rock into aggregate and has particle size ranging from 4 mm to dust size (> 0.075mm). It was procured from stone crusher plant producing 20 mm downgraded aggregate, M/s Maa Pitambara Stone situated at Neelbad, Bhopal (India).

Get Price

alternatives for sand as fine aggregate

Nov 21, 2016 Sand Alternatives for Aggregate. In a study released by the African Journal of Environmental Science and Technology, stone powder was pitted against sand as an alternative for fine aggregate. Sand is a naturally occurring material, while stone powder is a byproduct of crushing stone, usually for other projects.

Get Price

Replacement of recycled coarse aggregates with natural ...

2016-7-18  1. In their study, they use recycled coarse aggregates obtained by crushed concrete for concrete production. 2. Four different recycled aggregate concretes were produced; made with 0%, 25%, 50% and 100% of recycled coarse aggregates, respectively. 3. The mix proportions of the four concretes were designed in order to achieve the same

Get Price

Use of bottom ash and stone dust to make lightweight

2015-11-30  The production process of the lightweight aggregate is started with oven drying the stone dust and bottom ash over 24 h at 105 °C to remove moisture. Using the ball mill, each material was milled to less than 100-micron particle size and mixed according to designated proportions. 2.2.

Get Price

Use of Recycled Aggregates in Construction

2018-6-27  2 Use of Recycled Aggregates in Construction Contents EXECUTIVE SUMMARY 3 1 INTRODUCTION 6 1.1 General 6 1.2 Classification of Aggregates 6 2 MANUFACTURED AGGREGATES 7 2.1 Foamed Blast Furnace Slag (FBS) 7 2.2 Fly Ash Aggregates 8 2.3 Manufactured Sand 8 2.4 Polystyrene Aggregate 9 2.5 Expanded Clays, Shales and Slates 10 3 RECYCLED

Get Price

Experimental Investigation on Quarry Dust and Recycled ...

2019-6-6  Table 2 Properties of Fine Aggregate . Si .No Properties Results Sand Quarry Dust 1 Specific gravity 2.71 2.62 2 Fineness modulus 3.16 3.82 3 Water absorption (%) 1.55 6.49 4 Bulk density (kg/ m3) 1750 1540 . 2.3. Coarse Aggregate and Recycled Aggregate . The coarse aggregate passing through 20 mm and retaining 4.75 mm has to be used

Get Price

Choice Of Quarry Rock Dust Over Natural Sand As Fine

1 Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete 2 The concept of replacement of natural fine aggregate sand by quarry dust may help in many ways such as it is helpful to control environment pollution erosion of river bank

Get Price

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15  1. Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete. 2. The concept of replacement of natural fine aggregate (sand) by quarry dust may help in many ways such as it is helpful to control environment pollution, erosion of

Get Price

Study on Compressive Strength of Quarry Dust as Fine ...

2016-7-28  The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

Get Price

Use of bottom ash and stone dust to make lightweight

2015-11-30  The production process of the lightweight aggregate is started with oven drying the stone dust and bottom ash over 24 h at 105 °C to remove moisture. Using the ball mill, each material was milled to less than 100-micron particle size and mixed according to designated proportions. 2.2.

Get Price

Experimental Investigation on Quarry Dust and Recycled ...

2019-6-6  Table 2 Properties of Fine Aggregate . Si .No Properties Results Sand Quarry Dust 1 Specific gravity 2.71 2.62 2 Fineness modulus 3.16 3.82 3 Water absorption (%) 1.55 6.49 4 Bulk density (kg/ m3) 1750 1540 . 2.3. Coarse Aggregate and Recycled Aggregate . The coarse aggregate passing through 20 mm and retaining 4.75 mm has to be used

Get Price

7 III March 2019 doi.org/10.22214/ijraset.2019

C. Fine Aggregate The naturally available river sand used as fine aggregate. The fine aggregate Zone II passed through 4.75 mm and retained on 150 µ sieve is used confirming to the requirements of IS: 383-2016. D. Stone Dust Stone dust is collected from local stone crusher plant.

Get Price

PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

2019-4-21  Fine Aggregate In this concrete mixture sand is the fine aggregate. Sand is a naturally occurring granular material composed of finely divided rock and mineral particles. In terms of particle size as used by geologists, sand particles range in diameter from 0.0625 mm (or 1⁄ 16 mm) to 2 mm. Course Aggregate

Get Price

Development of sustainable concrete using silica fume and ...

2020-1-1  The durability of concrete in terms of acid attack and sulphate attack has been investigated. The results of the study have revealed that the 30% replacement of stone dust with fine aggregate and 10% replacement of silica fume with cement simultaneously can be

Get Price

What are the Materials for Replacement of Sand in ... -

2021-9-1  Crusher dust (quarry waste) is by product of stone crushers while producing coarse aggregate. Instead of disposing them in landfills, it can be best utilized as partial replacement to sand. In crusher dust, the particles (% finer than 150 microns) are generally high, a major concern limiting its percentage replacement to minimum with sand in a ...

Get Price

Production of Roller Compacted Concrete Made of

2021-7-13  As such, the recycled or waste materials from damaged structures can be used to replace coarse and fine aggregate, such as recycled asphalt pavement aggregate (RAP), recycled concrete aggregate (RCA), coal waste, silica fume, granulated blast furnace slag, and crumb rubber [9,10,11,12,13,14,15].

Get Price